1997 Acura NSX Service Manual PDF

The 1997 Acura NSX Service Manual provides comprehensive technical information for maintenance, repair, and service procedures for the Acura NSX sports car. This manual covers engine systems, transmission, suspension, brakes, electrical systems, body components, and troubleshooting guides specifically for the 1997 model year. Below are key sections for technical specifications, maintenance procedures, repair instructions, and troubleshooting.

1. Vehicle Specifications 2. Maintenance Schedules 3. Engine Service 4. Transmission & Drivetrain 5. Suspension & Steering 6. Brake Systems 7. Electrical Systems 8. Body & Interior 9. Diagnostic Procedures 10. Technical Bulletins 11. Troubleshooting Guide

Vehicle Specifications

Technical specifications for the 1997 Acura NSX including engine, dimensions, capacities, and performance data.

Specification	Details
Engine Type	3.0L DOHC 24-valve V6
Horsepower	252 hp @ 6600 rpm
Torque	210 lb-ft @ 5300 rpm
Transmission	5-speed manual / 4-speed automatic
Drivetrain	Rear-wheel drive
Curb Weight	3010 lbs (manual), 3153 lbs (automatic)
Fuel Capacity	18.5 gallons
Wheelbase	99.6 inches
Length	174.2 inches
Width	71.3 inches

Maintenance Schedules

Recommended maintenance intervals and service procedures for optimal vehicle performance.

Oil Change: Every 7,500 miles or 12 months
Spark Plugs: Replace every 30,000 miles
Timing Belt: Replace every 90,000 miles or 7 years
Brake Fluid: Replace every 3 years
Coolant: Replace every 5 years or 60,000 miles

WARNING! Always use Acura-approved fluids and follow torque specifications precisely.

Engine Service

Detailed procedures for engine maintenance, repair, and component replacement.

Valve Adjustment: Required every 30,000 miles
Timing Belt Replacement: Critical maintenance item
Oil Pump Service: Inspection and replacement procedures
Cooling System: Radiator, thermostat, and water pump service
Fuel System: Injector cleaning and fuel pump replacement

CAUTION! Engine components operate under high pressure and temperature - allow proper cooling before service.

Transmission & Drivetrain

Manual Transmission: Fluid change every 30,000 miles
Automatic Transmission: Fluid and filter service every 60,000 miles
Clutch System: Inspection and replacement procedures
Differential: Fluid service and seal replacement
Drive Axles: CV joint service and boot replacement

Suspension & Steering

Service procedures for suspension components and steering system maintenance.

Front Suspension: Double wishbone design, shock absorber replacement, ball joint inspection. Rear Suspension: Multi-link setup, alignment specifications. Steering: Power steering fluid service, rack and pinion inspection, tie rod replacement.

Brake Systems

Complete brake system service including ABS components and bleeding procedures.

Brake Pad Replacement: Front and rear procedures
Rotor Service: Machining and replacement specifications
ABS Service: Sensor replacement and system bleeding
Parking Brake: Adjustment and cable replacement

Tip: Always replace brake components in axle sets for optimal performance.

Electrical Systems

Wiring diagrams, component locations, and electrical system troubleshooting.

Battery: Testing and replacement procedures
Alternator: Output testing and replacement
Starter: Removal and installation
Lighting Systems: Headlight adjustment and bulb replacement
ECU: Diagnostic trouble codes and programming
Fuses & Relays: Location diagrams and testing

WARNING! Disconnect battery before performing electrical work to prevent short circuits.

Body & Interior

Body panel replacement, interior component service, and trim procedures.

Diagnostic Procedures

Step-by-step diagnostic routines for common issues and system malfunctions.

CAUTION! Use proper diagnostic equipment and follow safety procedures when troubleshooting electrical systems.

Technical Bulletins

Factory service bulletins and updates specific to the 1997 Acura NSX model.

Troubleshooting Guide

Symptom	Possible Cause	Corrective Action
Engine won't start	Battery, starter, fuel pump	Check battery voltage, test starter, verify fuel pressure
Poor acceleration	Clutch, fuel filter, sensors	Inspect clutch wear, replace fuel filter, check TPS
Brake vibration	Warped rotors, worn pads	Resurface or replace rotors, install new pads
Electrical issues	Ground connections, fuses	Check ground points, test fuses and relays
Overheating	Thermostat, radiator, water pump	Test thermostat, flush radiator, inspect water pump

Reset Procedures: ECU reset, maintenance reminder reset, ABS system reset.

Service Support: Contact Acura technical support for factory assistance.