2001 Acura Integra GSR Repair Manual

The 2001 Acura Integra GSR is a high-performance compact sports sedan featuring a 1.8L DOHC VTEC engine (B18C1), 5-speed manual transmission, 4-wheel independent suspension, front-wheel drive, and premium audio system. This repair manual covers maintenance procedures, troubleshooting, component replacement, and technical specifications for proper servicing and repair of all major systems.

Vehicle Specifications

Complete technical specifications for the 2001 Acura Integra GSR model.

Maintenance Schedule

Recommended maintenance intervals for optimal performance and longevity.

1. Oil and filter change: Every 7,500 miles or 12 months
2. Air filter replacement: Every 30,000 miles
3. Spark plugs: Replace every 60,000 miles
4. Timing belt: Replace every 90,000 miles
5. Coolant flush: Every 60,000 miles or 5 years
6. Brake fluid: Replace every 3 years
7. Transmission fluid: Replace every 30,000 miles

WARNING! Always use genuine Acura parts for optimal performance and warranty compliance.

Engine System

B18C1 VTEC engine maintenance and repair procedures.

1. VTEC system operation and troubleshooting
2. Valve adjustment procedure: 0.006-0.007 in (cold)
3. Timing belt replacement procedure
4. Water pump replacement
5. Fuel system service and injector cleaning
6. Ignition system maintenance
7. Compression testing specifications

CAUTION! Always disconnect battery before performing electrical work on engine components.

Transmission & Drivetrain

• Transmission Type: 5-speed manual (S80)
• Gear Ratios: 1st: 3.230, 2nd: 2.105, 3rd: 1.458, 4th: 1.107, 5th: 0.848
• Final Drive: 4.400:1
• Clutch: Hydraulic, single disc
• Fluid Capacity: 2.2 quarts Honda MTF
• Axles: Constant velocity joint type

Suspension & Steering

Double wishbone suspension system maintenance and alignment specifications.

Front Suspension: Double wishbone with coil springs, stabilizer bar

Rear Suspension: Double wishbone with coil springs

Steering: Rack and pinion with power assist

Alignment Specifications: Toe-in: 0° ± 2°, Camber: -0°30' ± 45', Caster: +2°00' ± 45'

Brake System

4-wheel disc brake system with ABS maintenance procedures.

1. Brake pad replacement procedure
2. Rotor inspection and machining specifications
3. Brake fluid bleeding procedure
4. ABS system troubleshooting
5. Caliper service and rebuilding

Tip: Always replace brake pads in axle sets for even braking performance.

Electrical System

Complete electrical system diagnostics and repair procedures.

1. Battery: 12V 50Ah, located in engine compartment
2. Alternator: 80 amp output
3. Starter motor: 1.4 kW
4. Fuse box locations: Under dash and engine compartment
5. Wiring diagrams and connector locations
6. Lighting system troubleshooting

WARNING! Disconnect battery before performing electrical repairs to prevent short circuits.

Body & Interior

Body panel replacement, interior component service, and trim procedures.

Troubleshooting Guide

Common issues and diagnostic procedures for the 2001 Integra GSR.

Technical Data

Torque specifications and technical reference data.

• Spark Plugs: NGK BKR6E-11, gap 0.039-0.043 in
• Oil Capacity: 4.5 quarts with filter
• Coolant Capacity: 6.3 quarts
• Fuel Tank: 13.2 gallons
• Tire Size: 195/55R15
• Wheel Size: 15x6 inches

Service Procedures

Step-by-step service procedures for common maintenance tasks.

Oil Change Procedure: Drain plug torque: 29 lb-ft, Filter torque: 12 lb-ft

Timing Belt Replacement: Requires special tools, recommended professional service

Brake Service: Caliper bolt torque: 25 lb-ft, Mounting bracket: 65 lb-ft

Service Contact: Acura dealership or certified technician recommended for complex repairs