Acura TSX Service Manual PDF

The Acura TSX Service Manual provides comprehensive technical information for maintaining and repairing the Acura TSX vehicle. This manual covers all major systems including engine, transmission, suspension, brakes, electrical, and body components. Below are key sections for maintenance procedures, specifications, troubleshooting, and service intervals.

1. General Information 2. Maintenance Schedule 3. Engine System 4. Transmission 5. Suspension & Steering 6. Brake System 7. Electrical System 8. Body & Interior 9. Troubleshooting Guide 10. Technical Specifications 11. Service Procedures

General Information

This service manual covers Acura TSX models from 2004-2014. Includes safety precautions, tool requirements, and general service information.

Section	Description
Safety Precautions	Important safety warnings and procedures
Service Tools	Required special tools for TSX maintenance
Vehicle Identification	VIN decoding and model identification
Maintenance Schedule	Recommended service intervals
Fluid Specifications	Oil, coolant, and other fluid requirements

Maintenance Schedule

Regular maintenance intervals for optimal vehicle performance and longevity.

Oil Change: Every 7,500 miles or 12 months
Tire Rotation: Every 7,500 miles
Air Filter: Every 30,000 miles
Spark Plugs: Every 105,000 miles
Transmission Fluid: Every 30,000 miles
Brake Fluid: Every 3 years
Coolant: Every 120,000 miles or 10 years

WARNING! Always use genuine Acura parts and fluids for optimal performance.

Engine System

Detailed service procedures for the K24 series engines used in Acura TSX models.

Engine Type: 2.4L DOHC i-VTEC 4-cylinder
Horsepower: 201 hp @ 7000 rpm
Torque: 172 lb-ft @ 4500 rpm
Compression Ratio: 11.0:1
Fuel System: Programmed Fuel Injection (PGM-FI)
Oil Capacity: 4.4 quarts with filter
Coolant Capacity: 6.3 quarts

Transmission

Service information for both manual and automatic transmissions.

Manual Transmission: 6-speed close-ratio gearbox with helical-type limited-slip differential.

Automatic Transmission: 5-speed automatic with Sequential SportShift.

Transmission fluid capacity: 2.6 quarts (manual), 3.1 quarts (automatic). Service includes fluid changes, clutch replacement, and shift linkage adjustment.

Suspension & Steering

Front and rear suspension service procedures and specifications.

Front Suspension: Double-wishbone with coil springs
Rear Suspension: Multi-link with coil springs
Steering Type: Variable power-assisted rack-and-pinion
Stabilizer Bars: Front and rear
Wheel Alignment Specifications: Camber, caster, toe settings

Tip: Always check wheel alignment after suspension component replacement.

Brake System

Complete brake system service including ABS and VSA systems.

Front Brakes: Ventilated discs, 11.8-inch diameter
Rear Brakes: Solid discs, 11.1-inch diameter
ABS System: 4-channel anti-lock braking system
VSA: Vehicle Stability Assist
Brake Fluid: DOT 3 or DOT 4
Pad Replacement: Detailed procedure with torque specifications

Electrical System

Wiring diagrams, component locations, and electrical troubleshooting.

Battery: 12V, 55Ah capacity
Alternator: 110A output
Starter Motor: 1.4 kW
Fuse Box Locations: Under-hood, driver's side, passenger's side
Lighting Systems: Headlights, taillights, interior lighting
Audio System: Radio, amplifier, speaker replacement
Climate Control: A/C and heating system service

WARNING! Disconnect battery before performing electrical work.

Body & Interior

Body panel replacement, interior trim, and accessory installation.

Includes procedures for door panel removal, seat replacement, dashboard components, and exterior body work. Covers both sedan and wagon models where applicable.

Troubleshooting Guide

Common issues and diagnostic procedures for Acura TSX.

Symptom	Possible Cause	Corrective Action
Engine won't start	Battery, starter, fuel system	Check battery voltage, fuel pressure, spark
Poor acceleration	Air filter, fuel filter, sensors	Replace filters, check MAF sensor
Brake vibration	Warped rotors	Resurface or replace brake rotors
Electrical issues	Battery, alternator, grounds	Test charging system, check ground connections
Transmission problems	Fluid level, sensors	Check fluid level and condition, scan for codes

Technical Specifications

Complete technical data for all Acura TSX models.

Dimensions: Length 183.3", Width 69.4", Height 56.7"
Wheelbase: 105.1 inches
Curb Weight: 3,230 lbs (manual), 3,274 lbs (automatic)
Fuel Capacity: 17.1 gallons
Tire Size: 215/50R17
Towing Capacity: Not recommended

Service Procedures

Step-by-step instructions for common maintenance tasks.

Oil and Filter Change: Complete procedure with torque specs
Brake Pad Replacement: Front and rear pad replacement
Spark Plug Replacement: Gap specifications and torque values
Timing Chain Service: Inspection and replacement procedure
Coolant Replacement: Proper bleeding procedure
Belt Replacement: Serpentine and timing belt procedures
Wheel Bearing Replacement: Front and rear bearing service

Service Support: Contact Acura customer service at 1-800-382-2238 or visit acura.com